While this use of pain pumps was a convenient way to relieve pain from surgery, it also resulted in a surprisingly high number of cases of a painful and debilitating deterioration of cartilage in the shoulder joint known as chondrolysis, specifically Postarthroscopic Glenhumeral Chondrolysis (PAGCL). The condition is permanent and many who suffer from it require shoulder replacement surgery.

Last year, the Food and Drug Administration (FDA) issued a notice to health care professionals informing them that use of pain pump devices and anesthetics in shoulder surgery were never approved by the agency. Yet, knowing this, pain pump manufacturers still instructed surgeons to use the pumps in this manner. As a result, a surprisingly high numbers of cases of chondrolysis were reported by patients who had used the pain pumps. As many as 63 percent of patients who used shoulder pain pumps are at risk of developing chondrolysis.

Several shoulder pain pump lawsuits have been filed by people who allege that they developed chondrolysis because the manufacturers of pain pumps failed to notify the medical community about the possible harm the devices could cause. More lawsuits are expected to be filed as more victims of these devices are diagnosed.

SOURCE: Pain Pumps › Studies link shoulder chondrolysis to pain pump devices

Arthritis in the shoulder is somewhat uncommon, with about 40,000 shoulder replacements being performed each year in the United States. By comparison, 450,000 knee and 230,000 hip replacements are performed annually. But the increasing reports of shoulder arthritis in young patients is alarming on many levels.

For starters, current shoulder replacement techniques do not adequately address the high function demands of young active patients. And while shoulder replacement may help relieve pain, many of these young patients who have shoulder replacement surgery will require further shoulder reconstructive surgery in the future.

The arthritic condition many of these young people suffer with is known as chondrolysis, a condition in which the cartilage in the shoulder joint wears away causing bone to rub against bone. There is no cure, and those who have chondrolysis often suffer from pain, limited mobility and debilitation. In many cases patients require shoulder replacement surgery.

As more and more reports of chondrolysis were being reported in patients following shoulder surgery, surgeons and researchers began to ask why. Laboratory data and clinical reports began pointing to the same likely culprit – the prolonged use of intra-articular local anesthetics administered directly into the shoulder joint by a pain pump device. Investigations found that this was not an FDA-approved use for the pain pump or the anesthetic; however, that didn’t stop pain pump manufacturers from instructing surgeons to use the device in such a way.

Surgeons are now understanding how they have been misled by the makers of pain pumps and with luck, the number of new chondrolysis reports will decrease in time. Until then, the only recourse victims have is to go after the pain pump manufacturers in court.

Source: Gerson Lehrman Group

SOURCE: Pain Pumps › Reports of young patients with arthritis in shoulder increasing

The nine are among a growing number of lawsuits filed against the makers of shoulder pain pumps that were used in patients following shoulder surgery. The devices have a catheter that is implanted into the surgical site and delivers regular does of anesthetics to the wound for up to 72 hours. Doctors soon began to see a connection between the use of the devices and a painful and debilitating condition known as chondrolysis.

The pain pumps were approved by the Food and Drug Administration (FDA) with the catheters placed in the shoulder tissue, but in the 1990s pain pump manufacturers sought approval from the FDA to have the catheters placed directly in the shoulder joint.

“To the FDA’s credit, they said no,” says Frank Woodson, shareholder with Beasley Allen Law Firm. “The FDA said, ‘If you want permission to do that, you’re going to have to do safety studies to determine whether or not that is a safe practice or a safe method to use your product.’ The companies did not do that and just went ahead and started advising physicians to place the pain pump catheter in the joint space.”

When the catheters were placed in the shoulder joint instead of the tissue, the medication began to eat away at the cartilage in the joint, causing the painful condition known as chondrolysis.

As a result, more than 140 lawsuits have been filed in state and federal courts against manufacturers of pain pump devices. “I hope this litigation will continue to educate the medical community to use pain pumps in a proper manner because if it is done in that way, then we should stop seeing these injuries occur,” Woodson said.

SOURCE: Pain Pumps › Lawsuits seek more than $68 million from pain pump manufacturers

The On-Q PainBuster pain pump offers an alternative to traditional intravenous and oral painkillers, which can leave patients feeling groggy. The pain pump uses a small balloon that holds a local anesthetic that is fed through a thin antimicrobial catheter that is inserted into the surgical site. The device injects the pain relief medication directly to the surgical site on a continuous basis for up to 72 hours following surgery. Following surgery, the patient goes home with the implanted device and after two or three days, the patient gently pushes out the catheter and discards the device.

Doctors who have used the pain pumps for hysterectomies and C-sections say the device helps women get up and about faster than using more traditional pain meds.

The I-Flow On Q PainBuster pain pumps have been a popular choice for orthopedic surgeons performing knee and shoulder surgeries. The pain pumps are designed and intended to be used with anesthetics that are administered continuously over time.

However, in shoulder surgeries in particular, the medication delivered directly to the surgery site has caused serious and permanent damage to the cartilage of the shoulder joint. This narrowing of the joint space is known as chondrolysis, a condition in which the complete or nearly complete loss of cartilage in the shoulder joint. Chondrolysis is an irreversible disabling and extremely painful condition.

A recent study published by The American Journal of Sports Medicine identified these intra-articular pain pumps as the likely cause of chondrolysis in shoulders.

There do not appear to be any reported problems with pain pump use following C-sections and hysterectomies at this time.

SOURCE: Pain Pumps › Pain pumps used following C-sections, hysterectomies

Post-operative pain pumps are a pain-management system that deliver medication directly to the surgical wound. The pumps came under fire recently after The American Journal of Sports Medicine linked intra-articular (or post-operative) pain pumps to cases of Postarthroscopic Glenohumeral Chondrolysis, a progressive degeneration of the cartilage in the shoulder resulting in pain and loss of motion. Chondrolysis is a chronic condition that often requires surgery.

Until the 1990s, the pumps delivered medication at a limited flow rate. In the late 1990s, manufacturers increased the amount of anesthetic used in the pain pumps. The lawsuit contends that continuous injection of the high-volume anesthetics into the shoulder can cause serious and permanent damage to the joint cartilage in the shoulder. The lawsuit also claims the pumps were marketed without first doing studies to determine the safety of the high-volume pain pumps or what damage could have occurred, instead encouraging use of both the pain pumps with the high doses of anesthetics.

“The plaintiffs are demanding compensatory damages for fraudulent misrepresentation, negligent misrepresentation negligence, strict liability, and breach of warranty,” according to the report.

SOURCE: Pain Pumps › Pain pump manufacturers named in lawsuit

Postoperative pain pumps are a pain-management system designed to deliver medication directly to the surgical wound or in close proximity to the nerves associated with the surgical area. A recent study published by The American Journal of Sports Medicine identified the post-operative pain pumps as the likely cause of articular chondrolysis, a progressive degeneration of the cartilage. Chondrolysis of the shoulder results in the narrowing of the joint space, which can cause pain and loss of motion. Chondrolysis is a chronic condition that often requires surgery.

As of July 2008, Health Canada had received eight reports of articular chondrolysis one month to one year following shoulder surgery. In all cases, the chondrolysis was thought to have been related to pain pumps. All patients listed in the incidence reports received bupivacaine, a local anesthetic, with epinephrine, a hormone and neurotransmitter.

Instructions for use on the label of the postoperative pain pumps discourages continuous intra-articular infusion of anesthetics, particularly when epinephrine is used.

In its announcement, Canada Health also urged health care professionals to report any adverse incidents following the use of pain pumps or other medical devices to the Health Products and Food Branch Inspectorate through the Inspectorate Hotline at 800-267-9675.

SOURCE: Pain Pumps › Health Canada issues warning about postoperative pain pumps

These devices have been used on thousands of patients nationwide, and based on our findings, hundreds appear to be at risk for this complication which results in severe pain, debilitating stiffness and eventual joint replacement surgery for many of those affected. We sent the results of our study to the manufacturers more than two years ago, but their response has so far been minimal to non-existent. It is time to get the word out and stop these devices from ruining any more lives.
Dr. Beck’s warning comes at an appropriate time now that football season is in full swing. Manufacturers report that the number of orthopedic surgeries rise sin the fourth quarter of each year tied to increased sports activity, particularly football and skiing. It appears that patients may tend to defer elective surgeries until the fourth quarter after annual insurance deductibles are satisfied.

The article, published in the October 2007 issue of The American Journal of Sports Medicine, demonstrates a strong association between the intra-articular (inside the joint space) use of high volume pain pumps following arthroscopic shoulder surgery and an otherwise unexplainable loss of hyaline cartilage in the shoulder joint. Dr. Brent Hansen, an orthopedic surgeon, was the senior author of the study. The complication discussed in the article, known as Postarthroscopic Glenohumeral Chondrolysis (PAGCL), is permanent and can lead to extreme pain and lifelong suffering in 63% of the patients that use the pain pumps. It is suggested that the complications may occur following open surgery as well.

Numerous lawsuits are pending against the companies that manufacture, market, or distribute the pain pumps, including Stryker, DJO Inc., I-Flow Inc., BREG Inc. and others. Included among the many claims in the lawsuits are the allegations that the manufacturers failed to instruct or warn the U.S. medical community that the safety of using the pain pumps in the shoulder joint space had not been established or that the continuous injections of commonly used anesthetics may cause permanent injury.

Our firm is looking into a number of claims from people across the country whose lives have been devastated by these pain pumps. These are supposed to be routine outpatient procedures, but the patients often endure several more surgeries, and most will eventually need complete shoulder replacement. We expect hundreds of individuals across the country to come forward with their own stories of ongoing pain and suffering they have experienced after using one of these devices. Frank Woodson, who is in our Mass Torts Section, is heading up a team that is investigating cases that include the use of pain pumps, not only in the shoulder, but in the knee, ankle and hip. If you need additional information relating to this matter, you can contact Frank at (334) 269-2343.

Source: Associated Press

November 15th, 2007

SOURCE: Pain Pumps › Pain pumps can cause cartilage damage